Air Canada Flight 646
| Accident summary | |
|---|---|
| Date | December 16, 1997 |
| Summary | Failed Landing |
| Site | Fredericton, New Brunswick |
| Passengers | 39 |
| Crew | 3 |
| Fatalities | 0 |
| Injuries (non-fatal) | 35 |
| Survivors | 42 (all) |
| Aircraft type | Canadair CL-600-2B19 (RJ100ER) Regional Jet |
| Operator | Air Canada |
| Registration | C-FSKI |
Air Canada Flight 646 was a flight from Toronto's Lester B. Pearson International Airport to Fredericton, New Brunswick, operated by Air Canada. On December 16, 1997, at 23:48 local time, the Canadair CRJ-100ER(CL-65) jet crashed after a failed go-around attempt in Fredericton. All passengers and crew survived, despite a 20-minute emergency response time and inadequate emergency training of the flight crew.
Crash
The weather in Fredericton was difficult—reported weather gave 100 feet (30 m) of vertical visibility and 1/8 of a mile in horizontal visibility. With the runway lights, the runway visibility was 1,200 feet (370 m) for landing on runway 15. At 200 feet (61 m) above ground level the captain approved the landing and the first officer, who was the pilot flying, responded that he would land the plane. Once the first officer disengaged the autopilot the aircraft drifted off the centre line of the runway and as the plane approached 80 feet (24 m) above ground level the first officer reduced the engine thrust to idle speed. The captain, knowing the plane was off centre and unsure how much runway was left, ordered a go-around.
Immediately, the first officer advanced the thrust levers, selected go-around mode for his flight director, and the aircraft began to pitch up. Almost immediately thereafter, the stick-shaker activated. The aircraft continued to pitch up and soon went into a stall.
The aircraft banked sharply to the right until the wingtip contacted the runway, bending the wing upwards by four feet. Then the aircraft levelled off until the nose contacted the runway. This broke the right winglet, broke off the nose landing gear, destroyed the radome, and caused heavy damage to the underside of the aircraft. All electrical power except the emergency lighting was lost. At this time engines had reached full power and the aircraft was rolling on its main gear, off the right side of the runway, through the snow, until it hit a ditch that ran parallel to the runway. This sent the plane airborne, where it flew about 1,000 feet (300 m), struck some trees, and finally came to rest. One large tree had entered the cabin through the main passenger door and cut a path in the fuselage through the first five rows of seats.
The flight attendant, during the crash sequence, shouted brace position commands and once the aircraft stopped, immediately evacuated the aircraft with the assistance of an off-duty flight attendant. Some passengers could not be extricated and required rescue from the Fire Services.
There was no fire on board the aircraft, no fatalities, and many on board were able to evacuate safely. A number of severely injured passengers had to be extracted from the aircraft with the "jaws of life" prior to receiving medical treatment.
Rescue
The CRJ (CL-65) aircraft was not equipped with an emergency locator transmitter, nor was one required. This, combined with the snow, fog, and darkness, hampered rescue efforts as the first responders did not arrive until 20 minutes after the incident. Passengers and crew also had no means of signalling rescuers to reveal their location. As well, the flight crew was unaware that pry-bars were part of the standard rescue gear aboard the aircraft. Thus they were unable to assist at least six individuals trapped inside the aircraft by the crash, until rescuers arrived.
Investigation
The Transportation Safety Board probe listed 29 causes and contributing factors and an additional 16 aggravating factors in the crash and rescue performance, including the following:
- Given the weather conditions, runway conditions, and first officer experience, the decision to allow the first officer to land the plane was questionable, though within policy.
- The wings had accumulated ice, degrading their performance, and reducing the maximum angle of attack before stall.
- The stick shaker worked as designed but the reduced wing performance reduced the warning time given by the stick shaker.
- A go-around without impacting the ground would not have been possible at the altitude it was ordered due to weather conditions and wing performance.
- The flight crew was not trained according to legal requirements in emergency procedures, including go-around, rescue and emergency exits.
- Stall-recovery training did not account for the weather conditions at the time of the crash.
- The published go-around procedure did not account for the time required for the engines spin up to sufficient thrust for go-around after idling.